Heating duct rusted out in slab

[Mike Huppi]

I did an inspection yesterday that the lower level ducts were in the concrete slab. I smelled moisture or mildue when I entered the home so when I pulled the vent cover on two registers I found they were rusted through and there was damp rocks and dirt because the duct was rusted through along with some carpenter ants.

Does anyone know of a repair for this or does the floor have to be jack hammered up to make new ducts

Similar Threads:

• Average cost of new duct work?
• Aluminum duct at the water heater
• Passive Solar Heating Help
• Laars Heating Systems Recalls Gas Boilers and Water Heaters
• Laars Heating Systems Recalls Gas Boilers and Water Heaters

[Jerry Peck]

Do what I suggested years ago when I found some like that, only the ones I found were half full of water - pump them full of concrete and install new ducts overhead.

Of the house I did, in Palm Beach (yeah, it was expensive, but it had NOT been maintained, you would think that people with money would also have common sense ... wait, why on earth would I think that ), and was two story, so it *was* a problem, but I saw no other solution. Not that big of a problem in the realm of things though, the house needed a LOT of remodeling and deferred (being nice) maintenance, so install the new ducts then.

[Steve Brooten]

I totally agree with Jerry. Ducts set in the concrete floor are going to be a problem. If not now, later. All of them I have seen have had rust or pest problems, and needed to be replaced. Pump them full of concrete and run them somewhere else! JMHO

[Mike Huppi]

Thanks thats basically what I told them the only problem is that it is on the bottom floor and they can not get to the joists so its going to be a ugly mess to say the least.

Thanks for the fast reply

[Thom Walker]

Mike,
Can you post a picture of one of the rusted through carpenter ants?

[Mike Huppi]

OH you vewy funny rusted carpenter ants Ha